Load capacity concerns on the 39mb Bighorn Traveler

[bwdt]

I have just ordered an 39mb with dual pane windows and slide toppers and plan on installing a washer dryer. I am very concerned about the available load capacity which will be less than 2000 lbs. Is there any way to increase this?
What frame is used on this unit, what is its load capacity? Are the limitations only in the suspension and axles? or just the tires. I think the available load will be around 1500 lbs. which just doesn't seem doable.

Any suggestions would be appreciated

[mlpeloquin]

You can change suspension and axles, but you cannot change the frame. So the rated capacity cannot be increased.

[Oldelevatorman]

Maybe do a little more research before ordering. If you start out overloaded that's not good. May have to look at something with more ccc.


Sent from my iPhone using Tapatalk

[TravelTiger]

Maybe do a little more research before ordering. If you start out overloaded that's not good. May have to look at something with more ccc.


Sent from my iPhone using Tapatalk

I agree, the Traveler line is a recreational-targeted unit. It looks like it's big Brother the BigHorn, but it is not designed for fulltime use. That may be why the cargo capacity is low. Then you're talking of adding dual pane windows with are a heavy add-on. Maybe look at a Big Country that will have more capacity and made for fulltiming. Adding dual pane will still add weight, but likely the BC will have more "room" for that.


Sent from my iPhone using Tapatalk

[bwdt]

I agree, the Traveler line is a recreational-targeted unit. It looks like it's big Brother the BigHorn, but it is not designed for fulltime use. That may be why the cargo capacity is low. Then you're talking of adding dual pane windows with are a heavy add-on. Maybe look at a Big Country that will have more capacity and made for fulltiming. Adding dual pane will still add weight, but likely the BC will have more "room" for that.


Sent from my iPhone using Tapatalk

I wanted a midbunk unit and if you look at the upper end units from Heartland, that have a midbunk they have the same weight capacity as the Traveler. I'm becoming disheartened with Heartland.

How much weight are the dual pane windows?

Whats funny is that if you added all of the options that heartland offers, you would probably be over weight when you got it.

[TravelTiger]

No, the Big Country is rated 16k, the Traveler 15.5K.

Someone else can probably comment on the weight of dual pane.


Sent from my iPhone using Tapatalk

[bwdt]

No, the Big Country is rated 16k, the Traveler 15.5K.

Someone else can probably comment on the weight of dual pane.


Sent from my iPhone using Tapatalk

You are correct, but the total capacity is 2100 lbs and the Traveler is 2050 lbs

[TravelTiger]

You are correct, but the total capacity is 2100 lbs and the Traveler is 2050 lbs

Hmmm, you are right, I did not realize. It appears the MidBunk plan is heavier than other similar length units.

Good luck in your decision! I think I read where dual pane windows added about 300lbs to their coach in 2015.

[TexasTraveler2017]

We found ourselves in a similar situation as well. We chose our new Gateway 3713CK because of the floorplan. The difference between it and a "normal" mid-bunkhouse was what really made my wife fall in love with it. However, the GVRW is 15,500 and after the options we added from the factory (double pane windows, awning toppers, generator prep) it left us with a CCC of 1196 lbs. Then on the way home I also picked up an Onan 6500 to put in there. So I'm already down to 896 of CCC.

Since we will be traveling extensively with 3 kids for the next several years, I already planned on immediately putting on the MORryde Independent Suspension and disc brakes when I drove to pick it up in Michigan. While at MORryde, I asked about the feasibility of upgrading to their 8K suspension given how little CCC was left and they felt it wouldn't be too harsh on the ride to do the 8K suspension with their lightest rated springs. I know this doesn't legally give me any additional CCC, but with that suspension/brakes and the new Sailun tires, I'm pretty confident that even if I'm over 15,500 some that things will be alright. The MORryde IS is definitely a beast which alone probably added 3 or 400 pounds to the weight of the coach. The weak link now would be the frame, but since Gateways are now built on the Cyclone line, maybe the frames are as strong as them? I don't know, but I also don't plan on seeing exactly how much I can overload it.

I know it isn't ideal, but there really aren't as many full-time coach options for families unless you go with a toy hauler . Most are just oriented towards couples.

[Shortest Straw]

I wanted a midbunk unit and if you look at the upper end units from Heartland, that have a midbunk they have the same weight capacity as the Traveler. I'm becoming disheartened with Heartland.

How much weight are the dual pane windows?

Whats funny is that if you added all of the options that heartland offers, you would probably be over weight when you got it.

I think what you need to decide is cargo capacity more important to you than the add-ons. Which do you need more? I do not think you can blame Heartland for your add-ons decreasing your cc.